進階搜尋


 
系統識別號 U0026-0812200914170126
論文名稱(中文) 鑭錳鎳(銦)氧化物之製備及其性質之研究
論文名稱(英文) Preparation and Characterization of Lanthanum Manganese Nickel (Indium) Oxides
校院名稱 成功大學
系所名稱(中) 化學工程學系碩博士班
系所名稱(英) Department of Chemical Engineering
學年度 96
學期 2
出版年 97
研究生(中文) 徐鈵琪
研究生(英文) Ping-chi Shiu
電子信箱 n3695148@mail.ncku.edu.tw
學號 N3695148
學位類別 碩士
語文別 中文
論文頁數 75頁
口試委員 口試委員-許澤勳
口試委員-林文崇
指導教授-高振豐
口試委員-楊文都
中文關鍵字 化學共沉  電阻係數 
英文關鍵字 chemical coprecipitation  electrical resistivity 
學科別分類
中文摘要 本實驗為化學共沉法製備不同比例的鑭錳鎳和鑭錳銦氧化物陶瓷粉末,此乃由於化學共沉法具有高均勻性、高反應性、高品質、以及精確的化學計量比。
以化學共沉法製得鑭錳鎳和鑭錳銦兩者之前導化合物,經冷凍乾燥後,未含鎳和銦者分別在800℃煅燒10小時、900℃煅燒10小時由XRD分析得知其主要化合物為鑭錳氧化物。
利用粒徑分析儀可知對於其鑭錳鎳氧化物(0.4μm~0.7μm )小於鑭錳銦氧化物(0.5μm~0.9μm )。
由電阻係數實驗可知鑭錳鎳氧化物(x=0.1mole,ρ=0.76Ω-cm)小於鑭錳銦氧化物(x=0.02mole, ρ=1.46Ω-cm)。
利用磁性測量儀器量測試樣之磁化係數與溫度關係變化之情形,知其均為具鐵磁性物質。
英文摘要 Chemical coprecipitation has high homogeneity,high reactivity,high quality and exact stochiometry.The goal of this study is that the lanthanum –manganese- nickel/indium oxide powders were prepared by coprecipitation method.
The precursors of lanthanum –manganese –nickel and lanthanum –manganese indium oxides with OH- ligands were prepared by coprecipitation.After freeze drying,the precursors were calcined at 800℃ for 10 h and were calcined at 900℃ for 10 h to obtain the corresponding compounds without nickel/indium respectively. It indicated from XRD patterns that the major compound was La0.96MnO3.05,respectively.
Laser Particle Size Distribution Analyzer was used to measure the particle size of the samples.It was found that the particle size lanthanum manganese nickel oxide (0.4μm~0.7μm )is low than that of lanthanum manganese indium oxide(0.5μm~0.9μm ).
From the electrical resistivity(Ohm-cm) one can obtain that the resistivity of lanthanum manganese nickel oxide (x=0.1mole,ρ=0.76Ω-cm)is low than that of lanthanum manganese indium oxide(x=0.02mole, ρ=1.46Ω-cm).
From the variations of susceptibility with temperature analyzed by SQUID,we found that products exhibit Ferromagnetism.
論文目次 目錄
中文摘要 ................I
英文摘要 ................II
誌謝 .............. ...III
目錄 ..................IV
表目錄 .............. .. VI
圖目錄 .................VII
第一章 緒論 ..............1
1-1 簡介 ...............1
1-2 研究目的 .............2
1-3 文獻回顧 .............3
第二章 理論基礎 ............9
2-1 化學溶液共沉法 ..........9
2-2 鈣鈦礦結構 ............11
2-3 煅燒與燒結 ............12
2-4 體密度 ..............14
2-5 磁性原理 .............15
第三章 實驗 ..............19
3-1 實驗藥品..............19
3-2 實驗儀器..............20
3-3 鑭錳鎳之(銦)氧化物之製備及性質測試.22
3-3-1 實驗流程.............22
3-3-2 溶液配製.............22
3-3-3 共沉...............23
3-3-4 靜置、過濾、乾燥及研磨......23
3-3-5 前導物粉體性質分析........23
3-3-6 煅燒及煅燒後粉末性質分析析....25
3-3-7 壓錠及燒結............26
3-3-8 燒結體的性質測定.........26
第四章 結果與討論...........27
第一部份:鑭錳鎳氧化物..........27
4-1 前導物粉體性質分析.........27
4-1-1 熱重分析.............27
4-2 煅燒及煅燒後粉末性質分析......29
4-2-1 X光繞射分析........... 29
4-2-2 添加鎳對陶瓷粉末之XRD影響.... 29
4-2-3 粒徑分佈及掃描式電子顯微鏡分析..33
4-3 燒結體的性質量測..........38
4-3-1 體密度..............38
4-3-2 磁性測定.............39
4-3-3 電阻量測.............40
第二部份:鑭錳銦氧化物..........42
4-4 煅燒及煅燒後粉末性質分析......42
4-4-1 添加鎳對陶瓷粉末之XRD影響.... 42
4-4-2 粒徑分佈及掃描式電子顯微鏡分析..45
4-5 燒結體的性質量測..........50
4-5-1 體密度..............50
4-5-2 磁性測定.............50
4-5-3 電阻量測.............51
第三部份:鍶添加於鑭錳鎳(銦)氧化物....54
第四部份:溶劑法製備鑭錳鎳氧化物.....55
第五章 總結...............58
文獻回顧 ................61
自述...................65
參考文獻 參考文獻
1. J. S. Reed,〝Introduction to the Principles of Ceramic Processing〞, Chap.4, John Wiley & Sons,New York. 1987.
2. K. Kamata, T. Nakajima,T. H. Hayashi and T. Nakamura,〝Nonstoichiometric Behavior and Phase Stability of Rare Earth Manganites at 1200℃(1). LaMnO3〞, Mat. res. Bull. , Vol. 13, 49-54, 1978.
3. Aaron Wold and Ronald J. Arnott,〝Preparation and Crystallographic Properties of the systems LaMn1-xMnxO3+δ and LaMn1-xNixO3+δ〞,J.Phys. Chem.Solids, Vol. 9, 176-180, 1959.
4. M. A. Gilleo,〝Crystallographic Studies of Pervoskite-Like Compounds.III. La(MxMn1-x)O3 with M=Co,Fe,Cr〞, Acta Cryst. , Vol. 10, 161-166, 1957.
5. I . O. Troyanchuk, S. N. Pastushonok, A. K. Bogush and V. I. Pavlov,〝Magnetic Properties of Nonstoichiometric Orthomanganites〞, Phys. Stat. Sol. , Vol. 118, 111-114, 1990.
6. A. P. Karavay,〝Lanthanum Manganite Phase Diagram〞, Kristall and Technik, Vol. 15, 11-16,1980.
7. Michael P. Rosynek and Denise T. Magnuson,〝Preparation and Characterization of Catalytic Lanthanum Oxide〞, J. Catal. ,Vol. 46, 402-413, 1977.
8. Edited by A. J. Downs,〝Chemistry of Aluminium, Gallium, Indium, Thallium〞, 1st edition, Blackie Academic & Professional, London, 286, 1993.
9. E. F. Milner, C. E. T. White,〝Kirk-Othmer Encyclopedia of Chemical Techology〞. 3rd edn. , Wiley, New York, 13, 207, 1981.
10. TKH Starke, GSV Coles, H Ferkel,〝High Sensitivity NO2 Sensors for Environmental Monitoring Produced Using Laser Ablated NanoCrystalline Metal Oxides〞, Sensors and Actuators B-Chemical, 85(3), 239-245, 2002.
11. C. Li, D. H. Zhang, X. L. Liu, S, Han, T. Tang, J. Han, C. W. Zhou,〝In2O3 Nanowires as Chamical Sensors〞,Applied Physics Letters, 82(10), 1613-1615, 2003.
12. J. B. Goodenough,〝Magnetism and the Chemical Bond〞, Chap. III, 1978.
13. J. B. Goodenough, A. Wold, R. J. Arnott and N, Menyuk,〝Relationship Between Crystal Symmetry and Magnetic Properties of Ionic Compounds Contaning Mn3+〞, Phys. Rev. , Vol. 124, 373-384, 1961.
14. J. B. Goodenough,〝Theory of the Role of Covalence in the Pervoskite-Type Manganites La,M(II)MnO3〞, Phys. Rev. , Vol. 100, 564-573, 1955.
15. E. E. Havinga,〝Magnetic Interactions Between Mn+3 Ions in Pervoskites〞, Philips Res. Repts. , Vol.21, 432-445, 1966.
16. E. E. Havinga,〝Ferrorlectric Pervoskites Contaning Manganese Ions〞, Philips Res. Repts. , Vol. 21, 49-62, 1966.
17. H. S. Spacil and C. S. Tedmon,〝Electrochemical Behavior of the Perovskite-Type Nd1-xSrxCoO3 in an Aqueous Alkaline Solution〞, J. Electrochem. Soc. 122, 159, 1975.
18. J. Drennan, C. P. Tavares and B .C. H. Steele,〝An Electron Microscope Investigation of phase in the system La-Ni-O〞, Mat. Res. Bull. , Vol. 17, 621-626, 1982.
19. Takami Kai and Takeshige Takahashi,〝Kinetics of the Methanation of Carbon Dioxide over a Supported Ni-La2O3 Catalyst〞, Canadian J. Chemical Engineering, Vol. 66, 343-347,1988.
20. H. Obayashi, Y. Sakurai and T. Gejo,〝Perovskite-Type Oxide as Ethanol Sensors〞,J.Solid State Chem. 17, 299, 1976.
21. Jun Tamaki, Tomoki Maekawa, Shigenori Matsushima, Norio Miura and Noboru Yamazoe,〝Ethanol Gas Sensing Properties of Pd-La2O3-In2O3 Thick Film Element〞, Chemistry Letters, 477-480, 1990.
22. H. R. Harrison, R. Aragon and C. J. Sandberg,〝Single Crystal Growth of the Transition Metal Monoxides by Skull Melting〞, Mat. Res. Bull. , Vol .15, No. 5, 571-580, 1980.
23. H. R. Harrison and R. Aragon,〝Skull Melter Growth of Magnetite (Fe3O4)〞, Mat. Res. Bull. , Vol. 13, 1097-1104,1978.
24. J. Takahashi, T. Toyoda, T.Ito and M. Takatsu,〝Preparation of LaNiO3 Powder from Coprecipitated Lanthanum-Nickel Oxalates 〞J. Mat. Sci. , 25, 1557-1562, .1990.
25. K. Vidyasagar, J. Gopalakrishan and C. N. R. Rao,〝Synthesis of Complex Metal Oxides Using Hydroxide, Cyanide, and Nitrate Solid Solution Precursors〞, J. Solid State Chemistry, 58, 29-37, 1985.
26. Hinh Hguyen, Jacques Choisent, Maryvonne Hervieu and Bernard Raveav,〝Oxygen Defect K2NiF4 –type Oxides: The Compounds La2-x/SrxCu4-x/2+δ〞J. Solid State Chemistry, 39, 120-127, 1981.
27. R. A. Mohanram, L. Ganapathi, P. Ganguly and C. N. R. Rao,〝Futher Evidence for the Coexistence of Localized and Itinerant 3d Electrons in LaNiO〞, J. Solid State Chemistry , 63, 139-147, 1986.
28. J. B. Goodenough and S.Ramasesha,〝Evolution of Three-Dimensional Character across the LaNiO Homologous Series with Increase in n1〞,Mat. Res. Bull. , Vol. 17, 383-390, 1982.
29. C. N. R Rao, D. J. Buttrey, N. Otsuka, P.Ganguly, H. R. Harrison, C. J Sandberg and J. M. Honig,〝Crystal Structure and Semiconductor-Metal Transition of the Quasi-Two-Dimensional Transition Metal Oxide,LaNiO〞,J.Solid State Chemistry , 51, 266-269, 1984.
30. B. Morten, M. Prudenziati, F. Sirotti, G. De Cicco and A. Alberigi-Quaranta,〝Magnetoresistive Properties of Ni-Based Thick Films〞, J. Mat. Sci. ,1, 118-122, 1990.
31. J. B. Goodenough,〝Interpretation of the Transport Properties of La2NiO4 and LaCuO Compound〞, Mat. Res. Bull. , Vol. 8, 423-432, 1973.
32. M. Suleman Malik, C. A. Hogarth and K. A. K. Lott,〝Relation Trend in the Electron Spin Resonance Phenomena in Copper Tellurite Galasses Containing NiO, CoO and Lu2O3〞, J. Mat. Sci. , 25, 1909-1912, 1990.
33. P. A Cox,〝Electronic Structure and Chemistry of Solids〞,(Oxford University Press.), 157, 1987.
34. Aaron Wold, Benjanmin Post and Ephraim Banks,〝Rare Earth Nickel Oxides〞, J. Electrochem. Soc. Vol. 79, 4911-4913, 1957.
35. M. Ernest, C. R. Robbins, F. M. Howard,〝Phase Diagrams for ceramicists〞, American Ceramic Society. , 135.
36. D. Lybye, F. W. Poulsen, M. Mogensen,〝Conductivity of A- and B-site doped LaAlO3,LaGaO3,LaScO3 and LaInO3 perovskites〞, Solid State Ionics, 128, 91-103, 2000.
37. E. Ruiz-Trejo, G. Tavizon, A. Arroyo-Landeros,〝Structure, Point Defects and Ion Migration in LaInO3〞, Journal of Physiscs and Chemistry of Solids, 64, 515-521, 2003.
38.H. He, X. Huang, L. Chen,〝The Effect of Dopant Valencr on the Structure and Electrical Conductivity of LaInO3〞, Electrochimica Acta, 46, 2871-2877, 2001.
39. Hongpeng He, Xuejie Huang, Liquan Chen,〝Sr-doped LaInO3 and Its Possible Application in a Single Layer SOFC〞, Solid State Ionics, 130, 9183-193, 2000.
40. Hong Peng He, Huang, Xue Jie Che, Li Quan,〝An Effective Way to Detect the Secondary Phase in Sr-doped LaInO3〞, Journal of Physics and Chemistry of Solids, 62, 701-709, 2001.
41. David W. Johnson, Jr. , 〝Nonconventional Powder Preparation Techniques〞, Ceram.Bull. , Vol. 60, 221-224, 1981.
42. J.A. Dean,〝Solubility Products〞,Lange Handbook of Chemistry,Chap. 5, McGraw-Hill BooK Company,New York,1970.
43. A. Benedetti, G. Fagherazzi, F. Pinna and S. Polizzi,〝Structural Properties of Ultra-Fine Zirconia Powders Obtanied by Precipitation Methods〞, J.Mat.Sci., Vol. 25, 1473-1478, 1990.
44. Boro Duricic, Drago Kolar and Milos Komac,〝Synthesis and Characterisitics of zirconia Fine Powders from Organic Zirconium Complexs〞J. Mat. Sci. , Vol.25, 1132-1136, 1990.
45. H. Nishizawa, N. Yamasaki, K. Matsuoka and H. Mitsushio,〝Crystallization and Transformation of Zirconia Under Hydrothermal Conditions〞, J. Am Ceram.Soc. , Vol. 65, 343-346, 1982.
46. L. Lerot, F. Legrand and P. De Bruycker,〝Chemical Control in Precipitation of Spherical Zirconia Particles〞, J. Mat. Sci. ,26, 2353-2358, 1991.
47. S. Al Dallal, M. N. Khan and Ashfaq Ahmed,〝Structural, Transport and Infrared studies of Oxide Spinel Zn1-xNixFeCrO4〞, J. Mat. Sci. , Vol. 25, 407-410, 1990.
48. W. D. Kinegry, H. K. Bowen and D. R. Uhlmann,〝Introduction to Ceramics〞, John Wiley & Sons, 899-900, 1976.
49. 守吉佑介,植松敬三,伊熊泰郎;〝Ceramics no 燒結〞;株式會社; p35-p64.
50. 水恭維谷,尾崎義治,木村敏夫;〝工業陶瓷製程〞; 復漢出版社; p99-p128.
51. 謝佩芫;“以化學共沉法製備鋰鋁錳(鎳、鈷)氧化物及其性質研究”國立成功大學化學工程研究所碩士論文(2003)。
52 . Chikazumi Soshin; “Physics of Magnetism”; John Wiley and Sons, 37~109, 1985
53. 張昫,李學養 譯;“磁性物理學”;聯經出版事業公司;p. 3-15。
54. F. F. Lange,〝Sinterability of Agglomerated Powders〞, J. Am. Ceram. Soc. , 67, 83-89, 1984.
55. M. D.sacks and H. A. Pask,〝Sintering of Mullite-Containing Materials: II, Effect of Agglomerated 〞, J. Am. Ceram. Soc. , 65, 70-77, 1982
56. C. G. Bergeron and S. H. Rishbud.〝Introduction to ceramics 〞, The American Ceramic Society Inc. , Columbus, Ohio, 1984.
論文全文使用權限
  • 同意授權校內瀏覽/列印電子全文服務,於2010-07-17起公開。
  • 同意授權校外瀏覽/列印電子全文服務,於2010-07-17起公開。


  • 如您有疑問,請聯絡圖書館
    聯絡電話:(06)2757575#65773
    聯絡E-mail:etds@email.ncku.edu.tw